生物滴滤系统处理模拟甲苯废气的研究
    点此下载全文
引用本文:高亭,戴珏,关杰,王晓璞,朱秋杰,范丹丹,王冠.生物滴滤系统处理模拟甲苯废气的研究[J].上海第二工业大学(中文版),2019,(2):90-96
摘要点击次数: 728
全文下载次数: 429
作者单位
高亭 1. 上海第二工业大学a. 环境与材料工程学院
b. 资源循环科学与工程中心, 上海201209
 
戴珏 1. 上海第二工业大学a. 环境与材料工程学院
b. 资源循环科学与工程中心, 上海201209
 
关杰 1. 上海第二工业大学a. 环境与材料工程学院
b. 资源循环科学与工程中心, 上海201209
 
王晓璞 1. 上海第二工业大学a. 环境与材料工程学院
b. 资源循环科学与工程中心, 上海201209
 
朱秋杰 1. 上海第二工业大学a. 环境与材料工程学院
b. 资源循环科学与工程中心, 上海201209
 
范丹丹 1. 上海第二工业大学a. 环境与材料工程学院
b. 资源循环科学与工程中心, 上海201209
 
王冠 2. 河北大学建筑工程学院, 河北保定071002 
基金项目:上海市高原学科– 环境科学与工程(资源循环科学与工程), 上海第二工业大学培育学科建设项目(EGD18YJ0029), 上海市联盟计划- 难题招标专项(LM201857), 上海第二工业大学研究生项目基金(EGD17YJ003) 资助
中文摘要:以模拟的甲苯废气为目标污染物, 探究生物滴滤(biological trickle filter, BTF) 系统在室温条件下空白系统、 启动挂膜以及稳定运行3 个阶段进气浓度、进气量及营养液喷淋速率对甲苯去除效率(η) 的影响。研究结果表 明: 在空塔试运行下, 甲苯进出口浓度差<3%, 空白系统各因素下甲苯吸附效率在3%~5% 之间, 对后续系统运行 的影响可忽略不计。BTF 系统在进气量15 L/min、进气浓度100~300 mg/m3 及营养液喷淋速率60 mL/min 的条件 下, 活性污泥挂膜时间<30 d; 当进气浓度增加至500 mg/m3, η >90%。系统稳定运行结果表明, 随着进气量和进气 浓度的增大, η 略微下降; 当进气量为5.25 L/min、进气浓度为100~1 000 mg/m3, η > 85%; 当营养液喷淋速率在 10~100 mL/min, η 稳定在95% 左右。
中文关键词:生物滴滤系统  甲苯  启动挂膜  稳定运行  去除效率
 
Study on the Treatment of Simulated TolueneWaste Gas by BiologicalTrickle Filter System
Abstract:At room temperature, the simulated toluene exhaust gas was used as the target pollutant, and the effect of toluene intake concentration, the intake air amount and the nutrient solution spray rate to toluene removal efficiency (η) were investigated in the three stages of the blank system, the start-up membrane and the stable operation of biological trickle filter (BTF) system. The results show that under the empty tower test operation, the difference of toluene inlet and outlet concentration is less than 3%, and the adsorption efficiency of toluene is between 3% and 5% under various factors of blank system, which has negligible impact on the subsequent system operation. When BTF system has an intake air volume of 15 L/min, an intake air concentration of 100~300 mg/m3 and a nutrient solution spray rate of 60 mL/min, the activated sludge filming time is less than 30 d. The gas concentration increases to 500 mg/m3, η is over 90%. During the stable operation phase of the system, ηgradually decreases with the increase of the intake air amount and the toluene intake concentration; when the intake air amount is 5~25 L/min and the intake air concentration is 100~ 1000 mg/m3, η is more than 85%;changing the spraying rate of nutrient solution to 10~100 mL/min, ′ is approximately stable at 95%.
keywords:biological trickle filter system  toluene  film forming start up  stable operation  removal efficiency
查看全文  查看/发表评论  下载PDF阅读器
上海第二工业大学学报编辑部 版权所有
地址:中国 上海市 浦东新区金海路2360号 邮编:201209
电话:021-50216814,传真:021-50216005  京ICP备09084417号